AUTONET TV BLOG

Don't be Fuelish (Signs Fuel Pump is Failing)

A driver of a large SUV loaded with equipment was heading on a 7-hour work trip when he stopped at a gas station to refuel.  When he went to restart his SUV, it turned over but wouldn't catch.  Try as he might, he was never able to get it started again. 

Of course there are many things that can cause those symptoms, but the next day he had his SUV towed to a service repair facility.  Using their test equipment, they were able to pinpoint the problem.  His fuel pump had failed.  The pump, which was located in the fuel tank, had to be replaced, and after awhile he was back on the road, delayed, but happy to be up and running again. 

What had happened is that the pump was not strong enough to deliver adequate  fuel to his engine, vital to being able to start it.  It had delivered just enough pressure in the morning to get it started the first time, but it was on its last legs.  He had been having trouble starting his SUV in the days leading up to this trip, a clue that something was wrong. 

The engine relies on a certain pressure of fuel from the pump to run properly, and there are some other signs to be aware of that your fuel pump may need to be replaced.  If you are putting strain on your engine, such as going uphill or hauling a big load, and the engine sputters, it may be a sign that the pump isn't delivering that consistent pressure.  Another warning sign is if your engine is running hot and then stalls.  That could mean your fuel pump is getting weak.

Sometimes you might notice your vehicle suddenly speeds up on its own or your fuel economy goes from good to poor in a short time.  If your fuel gauge shows you have plenty of fuel in the tank and your engine stalls, that's another possible sign of a failing fuel pump. 

Technicians have special equipment to see where the fuel problems are, and there are many possibilities.  Have your vehicle checked before you're left stranded.  Oh, and one more tip to prolong the life of your fuel pump.  Since it is cooled and lubricated by the fuel in your tank, make sure you keep at least a quarter of a tank of fuel at all times.  Avoid your "low fuel" light going on and you may be helping yourself avoid having to replace your fuel pump. 

Garrigan's Auto Repair Shop
6465 E GOLF LINKS RD
TUCSON, AZ 85730
(520) 572-7505
http://garrigansautorepair.com

Low Power Mystery (Ignition Coil Service)

It's no fun when your vehicle just doesn't run the way it used to.   You may notice (especially in cold weather) the engine won't start easily or when it does start, it doesn't run smoothly. It may not have much power at all. You also may have had to stop at the gas station more often, a sign your fuel economy isn't what it used to be. 

There could be a few different things that cause those symptoms, but one culprit could be a bad ignition coil. The coil takes the voltage from your battery and multiplies it before that power is sent over to a spark plug. That allows the plug to fire off a good jolt of electricity that ignites the fuel in your cylinder and powers the engine. 

There's usually one ignition coil for each cylinder (or sometimes for a pair of cylinders). If only one of them is not pushing out enough electricity, it can cause big trouble with your engine performance.  Other signs of a bad ignition coil include engine backfire, an oil leak and your Check Engine light coming on.   When that light comes on and you have some of those other signs, you need to have your repair facility check things out fairly soon because you may be damaging your engine and wind up with a far more expensive repair.

A technician will check for a computer code to pinpoint which cylinder is having the problem.  Using other diagnostics, the technician can rule out other components that might be causing the engine to misfire.  Ignition coils usually last 100,000 miles/160,000 km, but other engine conditions can cause them to fail before then. 

Your service advisor may suggest getting all your coils replaced even though only one is malfunctioning. That's probably a good idea in a higher mileage vehicle since the other coils may be close to failure, too. It's also wise to do that if your vehicle's coils are located in a hard-to-reach spot so you likely won't have to spend the money for that labor again when another one fails.

Garrigan's Auto Repair Shop
6465 E GOLF LINKS RD
TUCSON, AZ 85730
(520) 572-7505
http://garrigansautorepair.com

If You Drive Like a Maniac (Aggressive Driving is Bad for a Vehicle)

When someone mentions driving like a maniac, they're not talking about you, surely? Besides the safety issues of aggressive driving, you should know that your vehicle will last a lot longer if you'll just mellow out a little.  Here are four traits good drivers follow if they want their vehicles to go the extra distance.

Cool—The driver who can't wait to get to the next stoplight is just shortening the life of his or her vehicle.  Jackrabbit starts and uneven acceleration hurts your engine because the valves and cylinder heads are stressed more.  All of those moving parts will wear out faster as well as other components that are connected.  That means things like the air conditioner, power steering pump… just about anything that attaches by a belt or a pulley.  Oh, and you'll be generating more heat.  Heat is one of a vehicle's worst enemies.

Warm—If you get in your cold vehicle which has been sitting overnight, start it up and rev the engine high, you've just put a lot of stress on your engine.  That's because you didn't let the oil (that's been sitting down in the oil pan at the bottom of the engine) get to the moving parts in order to lubricate them. Some manufacturers advise that you run your vehicle for about 30 seconds before you take off.  And if it's really cold out, you may be wise to let the engine run for a minute or two before putting a load on the engine.  Also, for the first 5-15 minutes, keep your RPMs on the low side and don't jam on the accelerator.

Smooth—You're trying to get somewhere in a hurry and have to jam on the brakes while traveling pretty fast.  Just that one time can do more damage to the brakes than you would think.  Lots of hard braking can overheat your brakes and damage your rotors, wearing them out way faster than someone who drives with a smoother touch.  Hard braking also strains suspension parts, tires and engine mounts.

Smart—You know what PRNDL stand for.  Those are the letters in your automatic transmission (Park, Reverse, Neutral, Drive, Low).  Here are another couple of letters: IQ.  A smart shifter never goes into R to D without completely stopping the vehicle, unless, of course, you're anxious to spend some big dollars on your automatic transmission. 

These days, it's common to get 200,000 miles/320,000 kilometers out of a vehicle, no problem.  It just takes regular maintenance (oil changes and regular service) and one other thing.  Showing off: showing off a little moderation in driving habits with a big payoff in the end. 

Garrigan's Auto Repair Shop
6465 E GOLF LINKS RD
TUCSON, AZ 85730
(520) 572-7505
http://garrigansautorepair.com

For 4x4s (Maintenance of 4x4 Vehicles)

Some people love 4x4 vehicles, the true 4-wheel drive works of engineering like Jeeps and 4x4 pickups that allow you to seemingly go anywhere on the planet. You can climb up a 40-degree rock trail with some planning and skill (always careful to protect the environment, of course), or you can get through the deepest snow.

But with that added capability comes additional complexity, drive-train components and other systems that less capable vehicles don't have.  And that is why when it comes to 4x4s, you have to maintain them a little differently from those vehicles that spend their lives on pavement.  Here are some of the key things to keep an eye on:

• Transfer case—This transfers power from the engine to the wheels.  A transfer case has fluid in it that needs to be changed at intervals recommended by the manufacturer.  Your service advisor will let you know how often that is and will keep track of your service dates.  You will need to make sure the transfer case seal is working properly.  Otherwise, transmission fluid could get in and cause damage that is costly to fix.  Some transfer cases have an electric motor that shifts it through gears, and its connections are often exposed to the elements, making them vulnerable to damage and corrosion.  Proper maintenance will keep those connections working like they should
• Front and rear differentials—These also have to have the right amount of fluid and should be checked regularly.  Your service advisor can let you know when you need that fluid changed as the owner's manual recommends.  It's important the service is performed correctly with the proper lubricant so it will work the way it is designed to.
• Brake lines—Those 4x4s practically beg to go into wet spots. They also are great machines to conquer snow: road salt, brine and all.  Moisture, salt and brake lines are a recipe for corrosion, so brake lines need to be inspected regularly.  There are anti-corrosion sprays or white lithium grease that can retard corrosion.  Remember, getting there is half the fun, but not being able to stop is no fun at all.

So enjoy your 4x4 and what it can do that other vehicles can't.  Just remember that even though it's tough on the outside, it needs special care to keep it going.  Oh, and remember to take care of the environment when you go off-roading, too.